a 16035 vineyard blvd. morgan hill, ca 95037 p 408 225 4314 f 408 225 2079 e www.allsensors.com all sensors all sensors all sensors all sensors all sensors all sensors ds-0102 rev a the miniature amplified output pressure sensors is based upon a proprietary technology to reduce all output offset or common mode errors. this model provides a calibrated amplified output with superior output offset characteristics. output offset errors due to change in temperature, stability to warm-up, stability to long time period, and position sensitivity are all significantly reduced when compared to conventional compensation methods. in addition the sensor utilizes a silicon, micromachined, stress concentration enhanced structure to provide a very linear output to measured pressure. these calibrated and temperature compensated sensors give an accurate and stable output over a wide temperature range. this series is intended for use with non-corrosive, non-ionic working fluids such as air, dry gases and the like. the output of the device is ratiometric to the supply voltage and operation from any d.c. supply voltage between 4.5 and 5.5 volts. low pressure (1? h 2 o to 30 ? h 2 o) sensors prime grade ? 0 to 1? h 2 o to 0 to 30? h 2 o pressure ranges ? matched pressure port volumes ? temperature compensated ( -25 to 85 c) ? calibrated zero and span ? medical instrumentation ? environmental controls ? hvac general description applications features miniature amplified low pressure sensors physical dimensions 0.10 typical (2.54) pin 1 2 3 4 0.62 (15.7) 0.50 (12.7) 0.30 (7.6) 0.080 o.d. (2.00) 0.380 b-port a-port equivalent circuit d1 version d2 version or g verison
miniature amplified low pressure sensors part number 1 inch-dx-p4v-mini 1 inch-g-p4v-mini 5 inch-dx-p4v-mini 5 inch-g-p4v-mini 10 inch-dx-p4v-mini 10 inch-g-p4v-mini 20 inch-dx-p4v-mini 20 inch-g-p4v-mini 30 inch-dx-p4v-mini 30 inch-g-p4v-mini 60 inch-dx-p4v-mini operating pressure 1 in h2o 0 - 1 in h2o 5 in h2o 0 - 5 in h2o 10 in h2o 0 - 10 in h2o 20 in h2o 0 - 20 in h2o 30 in h2o 0 - 30 in h2o 60 in h2o nominal span 4 v 4 v 4 v 4 v 4 v 4 v 4 v 4 v 4 v 4 v 4v proof pressure 100 in h2o 300 in h2o 200 in h2o 200 in h2o 200 in h2o 200 in h2o 300 in h2o 300 in h2o 500 in h2o 500 in h2o 500 in h2o burst pressure 200 in h2o 200 in h2o 300 in h2o 300 in h2o 300 in h2o 300 in h2o 500 in h2o 500 in h2o 800 in h2o 800 in h2o 800 in h2o standard pressure ranges supply supply voltage vs common-mode pressure lead temperature (soldering 2-4 sec.) +4.5 to +5.5 vdc 10 psig 250c pressure sensor characteristics maximum ratings temperature ranges compensated operating storage humidity limits -25 to 85 c -40 to 125 c -40 to 125 c 0 to 95% rh (non condensing) environmental specifications equivalent circuit for differential pressure d1 is the package with two pressure ports the same side, d2 has two ports the opposite sides.
a 16035 vineyard blvd. morgan hill, ca 95037 p 408 225 4314 f 408 225 2079 e www.allsensors.com all sensors all sensors all sensors all sensors all sensors all sensors ds-0102 rev a parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 1.0 2.0 2.25 10 5 10 0.05 maximum 2.10 2.35 60 0.25 2 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, gage pressure output span, note 5 offset voltage @ zero pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (5c-50c), note 2 minimum 3.90 0.15 nominal 1.0 4.0 0.25 10 15 10 0.05 maximum 4.10 0.35 60 0.25 2 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 5.0 2.0 2.25 5 5 5 0.05 maximum 2.10 2.35 40 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span performance characteristics for 1 inch-dx-p4v-mini performance characteristics for 1 inch-g-p4v-mini performance characteristics for 5 inch-dx-p4v-mini
miniature amplified low pressure sensors parameter, note 1 operating range, gage pressure output span, note 5 offset voltage @ zero pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 3.90 0.15 nominal 5.0 4.0 0.25 5 5 5 0.05 maximum 4.10 0.35 40 0.25 1 units mbar volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 10.0 2.0 2.25 5 5 5 0.05 maximum 2.10 2.35 20 0.25 1 units mbar volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, gage pressure output span, note 5 offset voltage @ zero pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 3.90 0.15 nominal 10.0 4.0 0.25 5 5 5 0.05 maximum 4.10 0.35 20 0.25 1 units mbar volt volt mvolt mvolt mvolt mvolt %fs %span performance characteristics for: 5 inch-g-p4v-mini performance characteristics for: 10 inch-dx-p4v-mini performance characteristics for: 10 inch-g-p4v-mini
a 16035 vineyard blvd. morgan hill, ca 95037 p 408 225 4314 f 408 225 2079 e www.allsensors.com all sensors all sensors all sensors all sensors all sensors all sensors ds-0102 rev a parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 20.0 2.0 2.25 5 5 5 0.05 maximum 2.10 2.35 20 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, gage pressure output span, note 5 offset voltage @ zero pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 3.90 0.15 nominal 20.0 4.0 0.25 5 5 5 0.05 maximum 4.1 0.35 20 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 30.0 2.0 2.25 5 5 5 0.05 maximum 2.10 2.35 20 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span performance characteristics for 20 inch-dx-p4v-mini performance characteristics for 20 inch-g-p4v-mini performance characteristics for 30 inch-dx-p4v-mini
miniature amplified low pressure sensors specification notes note 1: a ll parameters are measured at 5.0 volt excitation , for the nominal full scale pressure and room temperature unless otherwise specified . p ressure measurements are with positive pressure applied to the f ront p ort . note 2: s hift is relative to 25c. note 3: s hift is within the first hour of excitation applied to the device . note 4: m easured at one - half full scale rated pressure using best straight line curve fit . note 5: t he voltage added to the offset voltage at full scale pressure . n ominally the output voltage range is 0.25 to 4.25 volts for minus to plus full scale pressure . parameter, note 1 operating range, gage pressure output span, note 5 offset voltage @ zero pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 3.9 0.15 nominal 30.0 4.0 0.25 5 5 5 0.05 maximum 4.1 0.35 20 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span all sensors reserves the right to make changes to any products herein. all sensors does not assume any liability arising out of the application or use of any product or circuit described herein, neither does it convey any license under its patent rights nor the rights of ot hers. pressure response: for any pressure applied the response time to get to 90% of pressure applied is typically less than 100 useconds. parameter, note 1 operating range, differential pressure output span, note 5 offset voltage @ zero differential pressure offset temperature shift (-25c-85c), note 2 offset warm-up shift, note 3 offset position sensitivity (1g) offset long term drift (one year) linearity, hysteresis error, note 4 span shift (-25c-85c), note 2 minimum 1.90 2.15 nominal 60.0 2.0 2.25 5 5 5 0.05 maximum 2.10 2.35 20 0.25 1 units ?h2o volt volt mvolt mvolt mvolt mvolt %fs %span performance characteristics for 30 inch-g-p4v-mini performance characteristics for 60 inch-dx-p4v-mini
|
